Refrigerant Leak Repair in Melbourne, DeLand & The Villages, FL
An air conditioner does not use up refrigerant. If it is low, there is a leak somewhere. Adding refrigerant without finding the leak means you will pay for it again. Champion AC & Heating Repair’s EPA-certified technicians locate the leak, repair it when it makes sense, recharge the system to the manufacturer’s specification, and tell you honestly when replacement is the smarter move.
Call (321) 603-3802 in Melbourne, (386) 877-0405 in DeLand or (352) 763-8394 in Oxford. We are open 24 hours, and financing is available.
Signs of a refrigerant leak
- AC runs but blows cool-ish or warm air
- Ice on the indoor coil or the large copper line outside
- Hissing or bubbling noise near the indoor or outdoor unit
- Power bill climbing while comfort drops
- Oily residue on refrigerant fittings
- You needed a “top-off” last summer too
Our Services
How we find and fix leaks
- Confirm low charge with gauges and temperature readings, not guesswork.
- Locate the leak using electronic leak detection, bubble testing and, when needed, nitrogen pressure testing.
- Repair common leak points: flare fittings, Schrader valves, service valves, line sets, brazed joints.
- Evacuate and recharge to the manufacturer’s specified charge.
- Verify superheat or subcooling and cooling performance.
Evaporator coils in Florida often develop pin-hole leaks. When the coil itself is leaking, we give you prices for coil replacement and full system replacement side by side.
What the refrigerant transition means for you
The EPA’s phase-down under the AIM Act means new residential systems now use lower-impact refrigerants such as R-454B and R-32, instead of R-410A. Existing R-410A systems can still be legally serviced and repaired, but R-410A supply is shrinking and prices have been rising. Older systems that use R-22 (Freon), which has not been produced since 2020, are expensive to recharge.
If your system is older than about 10–12 years and has a major leak, ask us for a replacement quote alongside the repair price.
How we find refrigerant leaks
- Electronic leak detectors sense refrigerant at fittings, valves and coils.
- Bubble solution confirms the exact spot on a suspected joint.
- Nitrogen pressure testing pressurizes the system to reveal leaks that are hard to find.
- Standing vacuum tests confirm the system is tight before we recharge.
What affects leak repair cost
- Where the leak is: a valve core or flare fitting is a small repair, while an evaporator coil may need replacement
- The type and amount of refrigerant needed to recharge
- Whether parts are under manufacturer warranty
- Access to the air handler or line set
Why adding refrigerant isn't a fix
Topping off a leaking system only buys time. The refrigerant escapes again, the system loses efficiency, and running low on charge can overheat the compressor. Refrigerant handling is regulated by the EPA, and only certified technicians should recover or charge it. Finding and fixing the leak protects both your system and your wallet.
Why Florida homeowners choose Champion AC
- 20 years of experience with Florida homes
- Licensed and insured technicians
- All major brands serviced and installed
- Open 24/7, including nights and weekends
- Upfront pricing before any work starts
Refrigerant leak repair pricing, financing and guarantee
You see the price before we start, with no hidden fees. Financing is available for larger repairs and new equipment. Satisfaction guaranteed: we don’t leave until your system is working properly.
Refrigerant leak repair FAQs
How do I know if my AC is low on refrigerant?
Warm air, ice on the coil or lines, longer run times and higher bills are common signs. A technician confirms it with gauges and temperature measurements.
Is it worth fixing a refrigerant leak?
Often yes, on a newer system with an accessible leak such as a fitting or valve. On an older system with a leaking coil, the repair can approach the cost of a new system, so we price both.
Can I still get R-410A for my AC?
Yes. Existing R-410A systems can still be serviced. Supply is being phased down, so costs are higher than they were a few years ago.
Do you still service R-22 (Freon) systems?
Yes, but R-22 is no longer produced and recharging is expensive. For most R-22 systems with a leak, replacement is the better value.
Is AC refrigerant dangerous?
Refrigerant can cause frostbite on contact and displace oxygen in enclosed spaces. Leave it to certified technicians.
Can a leak be sealed with a stop-leak product?
We generally don’t recommend sealants. They can clog valves and metering devices and make future repairs harder.
How long does a refrigerant recharge last?
If the leak is fixed, the charge should last the life of the system. Without a repair, it may last only weeks or months.
Choose your area
We provide refrigerant leak repair across three service areas. Choose yours for local details, phone numbers and FAQs:
Ready to schedule refrigerant leak repair?
Call (321) 603-3802 in Melbourne, (386) 877-0405 in DeLand or (352) 763-8394 in Oxford. Use Instant Online Quotation or Schedule a Consultation. We are open 24/7.
